11.19.2021
Table of Contents
- In the engine compartment
- Fuse box
- Relay box
- In the passenger comparment
- Fuse box
- Relay blocks
The Aygo is a small city car sold by Toyota in Europe. It was first presented at the 2005 Geneva Auto Show. In this material, we will analyze in detail the fuse diagrams for Toyota Aygo (body AB10) 1st generation 2005, 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014 release with right and left hand drive.
Here you will find the locations and photos of the fuse blocks. Separately, we note the element responsible for the cigarette lighter.
In the engine compartment
General placement of the electronic components.
1 | Engine compartment fuse box |
2 | Driven anti-skid module |
3 | Relay unit |
4 | Left hand drive: Engine control module |
5 | Left hand drive: Glow plug relay |
6 | Right hand drive: Glow plug relay |
7 | Right hand drive: Engine control module |
The main fuse box is located near the battery, closer to the windshield. Below the headlamp is the relay box.
Fuse box
Photo - an example of the execution of the main unit.
Diagram | ||
---|---|---|
No. | Description | A |
1 | EFI 4 - 2WZ-TV: sequential multiport fuel injection system | 15 |
2 | H-LP RH (HI) - Up to 2.2012: Right headlamps | 10 |
DRL - From 2.2012: Daytime Running Lamps | 5 | |
3 | H-LP LH (HI) - Before 2.2012: Left headlamp, sensors and instruments | 10 |
FR FOG - From 2.2012: Front fog lamps | 20 | |
4 | H-LP RH (LO) - Before 2.2012: Right headlamps | 10 |
H-LP LH - From 2.2012: Left headlamp | 10 | |
5 | H-LP LH (LO) - Before 2.2012: Left headlamp, sensors and instruments | 10 |
H-LP RH - From 2.2012: Right-hand headlamps | 10 | |
6 | STA - 1KR-FE: multi-mode manual transmission, sequential multi-point fuel injection system. | 7.5 |
FAN # 2 - 2WZ-TV: cooling fan | 7.5 | |
7 | EFI # 2 - sequential multiport fuel injection system, multimode manual transmission | 7.5 |
8 | EFI # 3 - 2WZ-TV: Multiport Fuel Injection, Cooling Fan. | 10 |
MET - Sensors and meters | 5 | |
9 | AMT - 1KR-FE: Multi-mode manual transmission | 50 |
RADIATOR FAN - 2WZ-TV: cooling fan | 50 | |
10 | H-LP LH - Without DRL: Left headlamp | 10 |
Before 2.2012: DIMMER - with DRL: fuses"H-LP LH (HI)", "H-LP RH (HI)", "H-LP LH (LO)", "H-LP RH (LO)", daytime running light system | 10 | |
From 2.2012: SUB-LP - with DRL: fuses"DRL", "FOG FR" | 10 | |
11 | VSC # 2 - Anti-lock braking system and vehicle stability control system | 30 |
ABS # 2 - without VSC: anti-lock braking system | 25 | |
12 | AM2 - Starting system, fuses"IG1", "IG2", "STA" | 30 |
13 | HAZARD - Direction indicators, emergency flashers, sensors and meters | 10 |
14 | H-LP RH - Before 02.2012: Right-hand headlights. | 10 |
H-LP MAIN - From 02.2012: fuses "H-LP LH", "H-LP RH". | 20 | |
15 | DOME - Gauges and counters, interior lighting, audio system, tachometer. | 15 |
16 | EFI - 1KR-FE: Cooling Fan, Distributed Fuel Injection | 15 |
EFI - 2WZ-TV: Cooling Fan, Multiport Fuel Injection | 25 | |
17 | HORN - Sound Signal | 10 |
18 | Spare | 7.5 |
19 | Spare | 10 |
20 | Spare | 15 |
21 | RADIATOR -Tropic: cooling fan | 40 |
RADIATOR -Normal: cooling fan | 30 | |
22 | VSC1 - Anti-lock braking system and vehicle stability control system | 50 |
ABS1 - without VSC: anti lock braking system | 40 | |
23 | EMPS - Electric Power Steering | 50 |
24 | ALTERNATOR - 1KR-FE: Charging system,"EPS", "ABS (without vehicle stabilization system)", "VSC (with vehicle stabilization system)","RADIATOR", "AM1", "HTR", "PWR", " Fuses D / L "," DEF "," TAIL "," STOP "," OBD "," ECU-B " | 120 |
25 | EBD resistor | |
Purpose of relay modules | ||
R1 | A / C MAG - Air Conditioning Compressor Clutch | |
R2 | Starter (ST) | |
R3 | Engine control unit (EFI MAIN) | |
R4 | 1KR-FE: Toyota Aygo Fuel Pump Relay (C / OPN) | |
R5 | Horn relay | |
R6 | Cooling system fan No. 1 |
Relay box
Located below the headlamp.
Diagram | ||
---|---|---|
No. | Relay | |
R1 | Heater PTC1 | |
R2 | Heater PTC2 | |
R3 | Empty | |
R4 |
| |
R5 | Dimer (DIM) | |
No. | Fuse | A |
1 | No | - |
2 | PTC2-Heater | 80 |
3 | PTC1-Heater | 80 |
In the passenger comparment
General placement of the electronic components.
No. | Component |
1 | Power steering control module |
2 | Center connector |
3 | Multi-mode manual transmission control module |
4 | Power window relay |
5 | Left-hand drive models: |
Up to 02.2012: rear light relay | |
From 02.2012: Rear fog lamp relay. | |
6 | Door control module with receiver |
7 | Relay block #1 |
8 | Air conditioner amplifier |
9 | Left hand drive: fog lamp relay |
10 | Left hand drive: Navigation light relay |
11 | Fuse box |
12 | Airbag sensor assembly center |
13 | Right hand drive: Relay block #2 |
14 | Right-hand drive models |
Before 02.2012: Ignition relay (IG) | |
From 02.2012: Power window relay. | |
15 | Right-hand drive models |
Before 02.2012: Power window relay | |
From 02.2012: Rear fog lamp relay |
Fuse box
Cabin fuses are located behind a protective casing in blocks located on both sides of the speedometer.
To remove the protective box, you need to unscrew the three fastening screws located behind the steering wheel (turn the steering wheel to the sides to get to them with a screwdriver.
Diagram | ||
---|---|---|
No. | Decryption | A |
1 | STOP - Stop Lamps, high stop Lamp, anti-lock braking system, multimode manual transmission | 10 |
2 | Power Door Lock System, Wireless Remote Control System (D / L) | 25 |
3 | Heated rear window (DEF) | 20 |
4 | Daytime Running Lamp System, Tail Lamps, License Plate Lamps, Side Lamps, Headlamp Level Control, Instrument Panel Illumination (TAIL) | 7.5 |
5 | OBD On-Board Diagnostic System | 7.5 |
6 | ECU-B - Multi-mode manual transmission, daytime running lamps, vehicle stabilization system, sensors and instruments, rear fog lamp | 7.5 |
7 | Empty | |
8 | ECU-IG - Anti-lock braking system, vehicle stabilization system, electric power steering, cooling fan. | 7.5 |
9 | BACK UP - Reversing lights, power door locking system, wireless remote control system, power windows, rear window defogger, tachometer, air conditioning system, heating system | 10 |
10 | WIP - Windscreen wiper / washer for windscreen and rear window | 20 |
11 | Toyota Aigo Cigarette Lighter Fuse, Power Socket, AudioSystem(ACC) | 15 |
12 | IG1 - Windshield and rear window wiper / washer, ABS anti-lock braking system, electric power steering, cooling fan, reversing lamps, power door lock system, wireless remote control system, power windows, rear window defroster, tachometer, air conditioning, heating | 7.5 |
13 | IG2 - sequential multiport fuel injection system, SRS airbag system, gauges and instruments, daytime running lights, multi-mode manual transmission | 15 |
14 | Air Conditioner & Heater - A / C | 7.5 |
15 | AM1 - Fuses"ACC", "WIP", "ECU-IG", "BACK UP" | 40 |
16 | PWR - power windows | 30 |
17 | HTR - heating, air conditioning, fuse"A / C" | 40 |
Relay blocks
Description.
Block #1 | |
R1 | Accessories (ACC) |
R2 | Heater (HTR) |
R3 | Heated rear window (DEF) |
R4 | Left hand drive: Ignition (IG) |
Block #2 | |
R1 | Ignition (IG) |
R2 | Fog lamps (FOG) |
Related fuse diagrams
Toyota 4Runner (N210; 2002 - 2009) |
Toyota Raum (Z20; 2003-2011) |
Toyota Gaia (XM10; 1998-2004) |
Toyota Prius (XW50; 2015-2022) |
Toyota Avensis (T270; 2008-2019) |
Toyota Premio (T260), 2007 - 2016 |
Comments
Be the first to comment. Nobody responded to this post yet.
Add new comment